26
F. Shi et al. / Catalysis Communications 28 (2012) 23–26
80
60
40
20
0
Acknowledgments
CAT
HQ
50
The authors gratefully acknowledge the Centre of Analysis and
Testing of Northeast Normal University for providing the ICP-AES
analysis and Changchun University of Technology for all the support.
40
30
20
10
0
Appendix A. Supplementary data
Supplementary data to this article can be found online at http://
BQ
1st run
2nd run
3rd run
References
Fig. 4. Catalytic performance of Cu–Pd–ALG-30–1 in phenol hydroxylation. All reactions
were performed under the following conditions: phenol/catalyst amount ratio 20:1,
phenol/H2O2 molar ratio 1:2, solvent (water) 30 mL, temperature 70 °C, and time 2 h.
Product distribution given on a tar-free basis.
[1] D.P. Ivanov, L.V. Pirutko, G.I. Panov, Applied Catalysis A 415–416 (2012) 10.
[2] G.Y. Zhang, J.L. Long, X.X. Wang, Z.Z. Zhang, W.X. Dai, P. Liu, Z.H. Li, L. Wu, X.Z. Fu,
Langmuir 26 (2010) 1361.
[3] L.L. Lou, S.X. Liu, Catalysis Communications 6 (2005) 762.
[4] S. Kulawong, S. Prayoonpokarach, A. Neramittagapong, J. Wittayakun, Journal of
Industrial and Engineering Chemistry 17 (2011) 346.
constant (approximately 1.6:1) under different reaction conditions
and the distribution of CAT and HQ in the products is similar to the
value reported in the literature [23]. Additionally, regarding Cu2+
ions as the active sites in this reaction, the turnover frequency (TOF:
moles of reacted substrate over moles of Cu per hour) was also
employed to evaluate the reaction rate. Although no obvious changes
have been found in the conversion of phenol with the changing of the
content of Cu2+ ions, a conclusion could been obtained that the TOF
values of the Cu–Pd–ALG were higher than the Cu–ALG catalyst. An
interesting finding is that the introduction of Pd can greatly reduce
the formation of byproducts. Given on a tar-free basis, the selectivity
to benzoquinone (BQ) decreased to less than 0.5% (entries 2–8).
When the content of Pd2+ in catalyst increased, the selectivity to BQ
decreased. Considering the economic benefits and the catalytic activity
of the binary catalysts, the recyclability of the Cu–Pd–ALG-30–1 was
investigated by subjecting the catalyst systems to three cycles of
re-using (Fig. 4). Under the same condition, the conversion of phenol
decreased from 53.9% to 50.7%, however the CAT/HQ ratio showed
very little change, which illustrated excellent stability of the catalyst.
[5] P.Y. Chao, S.T. Tsai, T.C. Tsai, J. Mao, X.W. Guo, Topics in Catalysis 52 (2009) 185.
[6] X.Y. Qi, L.L. Zhang, W.H. Xie, T.H. Ji, R.G. Li, Applied Catalysis A 276 (2004) 89.
[7] L.J. Jian, C. Chen, F. Lan, S.J. Deng, W.M. Xiao, N. Zhang, Solid State Sciences 13
(2011) 1127.
[8] L.H. Callanan, R.M. Burton, J. Mullineux, J.M.M. Engelbrecht, U. Rau, Chemical
Engineering Journal 180 (2012) 255.
[9] Z. Wang, C.W. Kee, S.Y. Li, T.S.A. Hor, J. Zhao, Applied Catalysis A 393 (2011) 269.
[10] J. Hong, C. Wei, M. Chen, X. Wang, T. Zhang, Catalysis Communications 8 (2007)
593.
[11] C. Gennequin, M. Lamallem, R. Cousin, S. Siffert, F. AÏssi, A. AboukaÏs, Catalysis
Today 122 (2007) 301.
[12] A.I. Zouboulis, I.A. Katsoyiannis, Industrial and Engineering Chemistry Research
41 (2002) 6149.
[13] Y.C. Dong, W.J. Dong, Y.N. Cao, Z.B. Han, Z.H. Ding, Catalysis Today 175 (2011)
346.
[14] B.T. Stokke, O. Smidsrbd, P. Bruheim, G. Skjakbraek, Macromolecules 24 (1991)
4637.
[15] E. Torres, Y.N. Mata, A.L. Blazquez, J.A. Munoz, F. Gonzalez, A. Ballester, Langmuir
21 (2005) 7951.
[16] F.W. Shi, Y.G. Chen, L.P. Sun, L. Zhang, J.L. Hu, Catalysis Communications 25
(2012) 102.
[17] K. Sato, S. Hamakawa, M. Natsui, M. Nishioka, T. Inoue, F. Mizukami, Catalysis
Today 156 (2010) 276.
[18] X.B. Wang, Y. Guo, X.F. Zhang, Y. Wang, H. Liu, J.Q. Wang, J.S. Qiu, K.L. Yeung,
Catalysis Today 156 (2010) 288.
[19] A.N. Pestryakov, V.P. Petranovskii, A. Kryazhov, O. Ozhereliev, N. Pfänder,
A. Knop-Gericke, Chemical Physics Letters 385 (2004) 173.
[20] A. Rodrigues, P. Costa, C. Méthivier, S. Dzwigaj, Catalysis Today 176 (2011) 72.
[21] S.K. Papageorgiou, E.P. Kouvelos, E.P. Favvas, A.A. Sapalidis, G.E. Romanos,
F.K. Katsaros, Carbohydrate Research 345 (2010) 469.
[22] F. Baldi, D. Marchetto, D. Zanchettin, E. Sartorato, S. Paganelli, O. Piccolo, Green
Chemistry 12 (2010) 1405.
4. Conclusion
A series of ion‐crosslinked Cu–Pd–ALG dry beads catalysts has
been prepared and their outstanding catalytic performance for phenol
hydroxylation with H2O2 as an oxidant in water was reported. The
binary Cu–Pd–ALG dry bead catalysts have better catalytic activities
than Cu–ALG catalyst. The conversion of phenol was associated with
the immobilized content of the Cu2+ ions, and the introduction of
Pd2+ ions can reduce the selectivity to BQ effectively.
[23] A.L. Villa, C.A. Caro, C.M. Correa, Journal of Molecular Catalysis A: Chemical 228
(2005) 223.