6
30
CIESIELSKI et al.
–
1
4
. Raudaskoski, R., Turpeinen, E., Lenkkeri, R., Pon-
grácz, E., and Keiski, R.L., Catal. Today, 2009,
vol. 144, no. 3, p. 318.
ance of a band at 2928 cm corresponding to the b-
HCO -Cu group. Besides, an increase in the intensity
of methoxy CH O–Ce band located at 1065 cm was
2
–1
3
5
6
7
8
. Räuchle, K., Plass, L., Wernicke, H.-J., and Bertau, M.,
observed, indicating a synergetic interaction between
the support and the active metal phase. In the case of
palladium-copper catalyst, the additional bands were
Energy Technol., 2016, vol. 4, no. 1, p. 193.
. Inui, T., Hara, H., Takeguchi, T., and Kim, J.-B.,
Catal. Today, 1997, vol. 36, no. 1, p. 25.
–
1
identified at 2117 and 2175 cm . These bands were due to
the presence of gaseous CO, which was formed because
. Koizumi, N., Jiang, X., Kugai, J., and Song, C., Catal.
Today, 2012, vol. 194, no. 1, p. 16.
of CO dissociation through the RWGS reaction.
2
. Saito, M., Fujitani, T., Takeuchi, M., and Watanabe, T.,
Base on the IR measurement results as well as liter-
ature review, a reaction mechanism of methanol syn-
thesis reaction was proposed (Scheme 1).
Appl. Catal., A, 1996, vol. 138, no. 2, p. 311.
9. Arena, F., Italiano, G., Barbera, K., Bordiga, S., Bon-
ura, G., Spadaro, L., and Frusteri, F., Appl.Catal., A,
2008, vol. 350, no. 1, p. 16.
The reaction starts with the adsorption of both
10. Graciani, J., Mudiyanselage, K., Xu, F., Baber, A.E.,
hydrogen and CO molecules. The hydrogen adsorbs
2
Evans, J., Senanayake, S.D., Stacchiola, D.J., Liu, P.,
dissociatively on the copper metal surface to form
Hrbek, J., Sanz, J.F., and Rodriguez, J.A., Science,
hydrogen atoms, which then migrate to the metal-sup-
2014, vol. 345, no. 6196, p. 546.
port interface. At the same time, gaseous CO adsorbs
2
11. Sahibzada, M., Chem. Eng. Res. Des., 2000, vol. 78,
on oxygen support vacancies to form carbonates.
Next, the adjacent hydrogen atoms interact with the
carbonate groups, forming intermediate formate spe-
cies. The formed groups are further hydrogenated to
no. 7, p. 943.
12. Bahruji, H., Bowker, M., Hutchings, G., Dimitratos, N.,
Wells, P., Gibson, E., Jones, W., Brookes, C., Morgan, D.,
and Lalev, G., J. Catal., 2016, vol. 343, no. 1, p. 133.
methoxy species and water. In the next step, the 13. Chiavassa, D.L., Barrandeguy, J., Bonivardi, A.L., and
methoxy intermediates react with the formed water to
yield methanol and hydroxyl groups. In the final step,
Baltanás, M.A., Catal. Today, 2008, vols. 133–135,
no. 1, p. 780.
the hydroxyls are hydrogenated by atomic hydrogen to 14. Liang, X.-L., Dong, X., Lin, G.-D., and Zhang, H.-B.,
Appl. Catal., B, 2009, vol. 88, no. 3, p. 315.
form water.
1
5. Fujitani, T., Saito, M., Kanai, Y., Watanabe, T., Na-
kamura, J., and Uchijima, T., Appl.Catal., A, 1995,
vol. 125, no. 2, p. 199.
CONCLUSIONS
1
6. Shao, C., Fan, L., Fujimoto, K., and Iwasawa, Y., Appl.
This work confirms the promotion effect of palla-
dium on the activity and selectivity of copper catalysts
in the methanol synthesis reaction. The improvement
in the activity of bimetallic catalysts was explained by
the formation of Pd–Cu alloy. Additionally, the pres-
ence of supported palladium atoms promotes the acti-
vation of hydrogen due to the spillover effect, as evi-
denced by the low-temperature shifts of reduction
temperatures of catalysts towards. The obtained results
also revealed that the increase in copper content was
accompanied by simultaneous decrease in the total
acidity and specific surface area of the investigated
catalysts. This leads to the low catalytic activity of the
Catal., A, 1995, vol. 128, no. 1, p. 1.
17. Collins, S.E., Chiavassa, D.L., Bonivardi, A.L., and
Baltanás, M.A., Catal. Lett., 2005, vol. 103, no. 1, p. 83.
1
8. Zhang, L., Pan, L., Ni, C., Sun, T., Zhao, S., Wang, S.,
Wang, A., and Hu, Y., Int. J. Hydrogen Energy, 2013,
vol. 38, no. 11, p. 4397.
19. Sonneveld, E.J. and Visser, J.W., J. Appl. Crystallogr.,
1975, vol. 8, no. 1, p. 1.
2
0. Ahouari, H., Soualah, A., Le Valant, A., Pinard, L.,
Magnoux, P., and Pouilloux, Y., React. Kinet. Mech.
Cat., 2013, vol. 110, no. 1, p. 131.
21. Zhang, B., Hui, S., Zhang, S., Ji, Y., Li, W., and Fang, D.,
J. Nat. Gas Chem., 2012, vol. 21, no. 5, p. 563.
catalysts. FT-IR in situ studies of CO hydrogenation
2
22. Huang, C., Chen, S., Fei, X., Liu, D., and Zhang, Y.,
2–
–
showed the occurrence of HCO and CH O species
3
Catalysts, 2015, vol. 5, no. 4, p. 1846.
on the surface of the support. The presence of these
2
3. Schuyten, S., Guerrero, S., Miller, J.T., Shibata, T.,
and Wolf, E.E., Appl. Catal., A, 2009, vol. 352, no. 1,
p. 133.
forms implies that CO is adsorbed on the surface of
2
the support and then is hydrogenated to intermediate
surface species in subsequent reaction steps.
24. Mierczynski, P., Ciesielski, R., Kedziora, A., Shtyka, O.,
and Maniecki, T.P., Fibre Chem., 2016, vol. 48, no. 4,
p. 271.
REFERENCES
25. Jiang, X., Koizumi, N., Guo, X., and Song, C., Appl.
Catal., B, 2015, vols. 170–171, no. 0, p. 173.
1
. Davis, S.J., Caldeira, K., and Matthews, H.D., Science,
010, vol. 329, no. 5997, p. 1330.
. Pontzen, F., Liebner, W., Gronemann, V., Rothaemel,
2
26. Jiang, X., Wang, X., Nie, X., Koizumi, N., Guo, X.,
and Song, C., Catal. Today, 2018, vol. 316, no. 1, p. 62.
2
M., and Ahlers, B., Catal. Today, 2011, vol. 171, no. 1, 27. Hu, B., Yin, Y., Liu, G., Chen, S., Hong, X., and
p. 242.
Tsang, S.C.E., J. Catal., 2018, vol. 359, no. 1, p. 17.
. Ansari, M.B., and Park, S.-E., Energy Environ. Sci., 28. Melián-Cabrera, I., López Granados, M., and Fi-
012, vol. 5, no. 11, p. 9419. erro, J.L.G., Catal. Lett., 2002, vol. 79, no. 1, p. 165.
3
2
KINETICS AND CATALYSIS
Vol. 61
No. 4
2020