R.S. Malkar, G.D. Yadav
CB = CBo (1 − XB)
AppliedCatalysisA,General560(2018)54–65
Appendix A. Supplementary data
(8a)
(8b)
(8c)
Supplementary data associated with this article can be found, in the
CA = CAo − CBoXB = CBo (M − XB)
CD = CBoXB
References
Substituting in terms of XB and integrating Eq. (8) for M ≠ 1, we get;
[1] K. Schlichte, T. Kratzke, S. Kaskel, Microporous Mesoporous Mater. 73 (2004)
[2] K.-T. Li, C.-Y. Wang, Chem. Eng. Commun. 203 (2016) 1641–1647, http://dx.doi.
M − X
−
ln(1 − XB) − [KB (M − 1) − M]ln(
Experimental values were used for checking the validity of the
model. Based upon above equations and using Polymath 6.0 software
different rate constants were calculated as presented in Table 5. Ar-
rhenius plot (Fig. 19) was made to calculate activation energy which is
13.98 kcal/mol concluding that the reaction is kinetically controlled.
B ) = [kSR KB (M − 1)wt]
M
(9)
[3] H. Yu, H. Fang, H. Zhang, B. Li, F. Deng, Catal. Commun. 10 (2009) 920–924,
[4] J. Yang, F. Zhang, X. Wang, D. He, G. Wu, Q. Yang, X. Hong, Y. Wu, Y. Li, Angew.
[5] P. Yin, T. Yao, Y. Wu, L. Zheng, Y. Lin, W. Liu, H. Ju, J. Zhu, X. Hong, Z. Deng,
G. Zhou, S. Wei, Y. Li, Angew. Chem. - Int. Ed. 55 (2016) 10800–10805, http://dx.
[6] C. Zhao, X. Dai, T. Yao, W. Chen, X. Wang, J. Wang, J. Yang, S. Wei, Y. Wu, Y. Li, J.
[7] H. Liu, L. Chang, L. Chen, Y. Li, J. Mater. Chem. A 3 (2015) 8028–8033, http://dx.
3.2.11. Catalyst reusability and leaching test
After completion of reaction, reaction mixture was centrifuged to
separate the catalyst. It was then refluxed with methanol for 3–4 times
to get rid off adsorbed reactants and products. Then it was dried in oven
for 12 h and reused for next reaction. There was a marginal loss of
catalyst quantity during washing. It was made up before each reaction
of reusability. Reused catalyst was stable up to two use after that
conversion started decreasing (Fig. 20). For 4th reuse there was 10%
decrease in conversion. As stated above, exposure to acidic solution
makes catalyst weaker and starts disintegrating. Therefore after 3 cycle
conversion of benzoic anhydride started decreasing.Therefore the cat-
alyst is stable and reusable upto 3 cycles. ICP-AES analysis was carried
out initially of reaction mass and it was found that leaching of tungsten
from DTP was below detection level. Whereas reaction mass was again
analyzed by ICP-AES after 3rd cycle of reusability and 9% DTP leaching
was observed.
[8] H. Ramezanalizadeh, F. Manteghi, Monatshefte Für Chem. - Chem. Mon. 148 (2017)
[9] K.S. Park, Z. Ni, A.P. Côté, J.Y. Choi, R. Huang, F.J. Uribe-Romo, H.K. Chae,
M. O’Keeffe, O.M. Yaghi, Proc. Natl. Acad. Sci. U. S. A. 103 (2006) 10186–10191,
[10] X.L. Yang, L.M. Qiao, W.L. Dai, Microporous Mesoporous Mater. 211 (2015) 73–81,
[11] M. Chen, J. Yan, Y. Tan, Y. Li, Z. Wu, L. Pan, Y. Liu, Ind. Eng. Chem. Res. 54 (2015)
[12] M. Saikia, D. Bhuyan, L. Saikia, Appl. Catal. A Gen. 505 (2015) 501–506, http://dx.
[13] A.E.R.S. Khder, H.M.A. Hassan, M.S. El-Shall, Appl. Catal. A Gen. 487 (2014)
[14] J. Juan-Alcañiz, E.V. Ramos-Fernandez, U. Lafont, J. Gascon, F. Kapteijn, J. Catal.
[15] X.-S. Wang, Y.-B. Huang, Z.-J. Lin, R. Cao, Dalt. Trans. 43 (2014) 11950–11958,
[16] L. Bromberg, X. Su, T.A. Hatton, ACS Appl. Mater. Interfaces 5 (2013) 5468–5477,
[17] L.H. Wee, S.R. Bajpe, N. Janssens, I. Hermans, K. Houthoofd, C.E. a Kirschhock, J. a
Leaching of DTP molecule in the reaction mixture was also studied
by a hot filtration test for 1st and and 2nd time reused catalyst. The
reaction was stopped after 90 min and the reaction mixture centrifuged
to separate the catalyst. Here reaction mass was analyzed by GC to get
57% conversion of benzoic anhydride. The clear reaction mixture was
again fed to the reactor and continuously stirred for next 2 h at the same
reaction conditions. It was found that there was no change in conver-
sion of benzoic anhydride after 2 h. Thus it proveed that there was no
leaching of DTP molecules from ZIF-8 cage.
[18] S.S. Nadar, V.K. Rathod, Int. J. Biol. Macromol. 95 (2017) 511–519, http://dx.doi.
[19] J. Liu, J. He, L. Wang, R. Li, P. Chen, X. Rao, L. Deng, L. Rong, J. Lei, Sci. Rep. 6
[20] M. Ammar, S. Jiang, S. Ji, J. Solid State Chem. 233 (2016) 303–310, http://dx.doi.
[21] K. Liang, R. Ricco, C.M. Doherty, M.J. Styles, S. Bell, N. Kirby, S. Mudie, D. Haylock,
[22] R.S. Malkar, G.D. Yadav, Ind. Eng. Chem. Res. 56 (2017) 8437–8447, http://dx.doi.
[23] M.S. Tiwari, A.B. Gawade, G.D. Yadav, Green. Chem. 19 (2017) 963–976, http://dx.
4. Conclusion
[24] J. Molleti, M.S. Tiwari, G.D. Yadav, Chem. Eng. J. 334 (2018) 2488–2499, http://
Cinnamyl benzoate was synthesized successfully over a DTP en-
capsulated ZIF-8. For the formation of complete rhombic tetrahedron
crystals, time of nucleation has been optimized up to 12 h. For max-
imum catalytic activity and uniform encapsulation of DTP, different
loadings of DTP were studied. From which 18%-DTP@ZIF-8_12 h was
optimized for all reactions. Excess DTP leads to improper crystallization
of ZIF-8 and it can be seen in SEM images. All the catalysts were fully
characterized and tested against benzoic anhydride conversion to cin-
namyl benzoate. Reaction parameters were studied and kinetic model
developed. Reaction follows Eley-Rideal mechanism with activation
energy 13.98 kcal/mol. Therefore the reaction is kinetically controlled.
[27] S.R. Venna, J.B. Jasinski, M. a Carreon, J. Am. Chem. Soc. 132 (2010) 1–6, http://
[28] S. Lazare, D. Bazer-bachi, F. Bonnier, E. Soyer, A. Quoineaud, N. Bats, J. Am. Chem.
[29] W. Dai, N. Tian, C. Liu, L. Yu, Q. Liu, N. Ma, Y. Zhao, (Zn, Ni, Cu) -BTC
Functionalized With Phosphotungstic Acid for Adsorptive Desulfurization in the
[30] N.A.H. Md Nordin, S.M. Racha, T. Matsuura, N. Misdan, N.A. Abdullah Sani,
[31] Y. Hu, H. Kazemian, S. Rohani, Y. Huang, Y. Song, Chem. Commun. 47 (2011)
Acknowledgments
[32] Y. Zhang, V. Degirmenci, C. Li, E.J.M. Hensen, ChemSusChem. 4 (2011) 59–64,
R. S. Malkar acknowledges University Grants Commission (UGC),
India for the award of fellowship in Green Technology. G. D. Yadav
acknowledges support from R. T. Mody Distinguished Professor
Endowment and J. C. Bose National Fellowship of Department of
Science and Technology, Government of India.
[33] M. Jian, B. Liu, R. Liu, J. Qu, H. Wang, X. Zhang, RSC Adv. 5 (2015) 48433–48441,
[34] S.H. Pang, C. Han, D.S. Sholl, C.W. Jones, R.P. Lively, Chem. Mater. 28 (2016)
[35] C.-Y. Sun, C. Qin, X.-L. Wang, G.-S. Yang, K.-Z. Shao, Y.-Q. Lan, Z.-M. Su, P. Huang,
64