Commercial Food Equipment Service Association P_0000283583 D_0000307072




MATERIAL SAFETY DATA SHEET
EQUILON MSDS: 56230E-08 01/04/99
AEROSHELL(R) GREASE 5
TELEPHONE NUMBER:
24 HOUR EMERGENCY ASSISTANCE GENERAL MSDS ASSISTANCE
EQUIVA SERVICES: 877-276-7283 877-276-7285
CHEMTREC: 800-424-9300
NAME AND ADDRESS
EQUILON ENTERPRISES LLC
PRODUCT STEWARDSHIP
P.O. BOX 674414
HOUSTON, TX 77267-4414
_______________________________________________________________________________
SECTION I NAME
_______________________________________________________________________________
PRODUCT: AEROSHELL(R) GREASE 5
CHEM NAME: MIXTURE (SEE SECTION II-A)
CHEM FAMILY: LUBRICATING GREASE
SHELL CODE: 70025
HEALTH HAZARD: 1 FIRE HAZARD: 1 REACTIVITY: 0
_______________________________________________________________________________
SECTION II-A PRODUCT/INGREDIENT
_______________________________________________________________________________
NO. COMPOSITION CAS NO. PERCENT
--- ----------- ------- -------
P AEROSHELL GREASE 5 MIXTURE 100
1 SOLVENT REFINED; HYDROTREATED RESIDUAL OIL 64742-57-0 89.0
2 INORGANIC CLAY 1302-78-9 6.0
3 FATTY ACID AMIDES 68910-93-0 3.0
4 OTHER COMPONENTS MIXTURE <3.0
NFPA HAZARD RATING: HEALTH 0 FIRE 1 REACTIVITY 0
_______________________________________________________________________________
SECTION II-B ACUTE TOXICITY DATA
_______________________________________________________________________________
NO. ACUTE ORAL LD50 ACUTE DERMAL LD50 ACUTE INHALATION LC50
--- --------------- ----------------- ---------------------
P NOT AVAILABLE
BASED UPON DATA AVAILABLE, COMPONENT 4 IN THIS PRODUCT IS NOT
HAZARDOUS UNDER OSHA HAZARD COMMUNICATION (129 CFR 1910.1200).
_______________________________________________________________________________
SECTION III HEALTH INFORMATION
_______________________________________________________________________________
THE HEALTH EFFECTS NOTED BELOW ARE CONSISTENT WITH REQUIREMENTS UNDER THE OSHA
HAZARD COMMUNICATION STANDARD (29 CFR 1910.1200).
EYE CONTACT: MAY BE MILDLY IRRITATING TO THE EYES.
SKIN CONTACT: PROLONGED OR REPEATED CONTACT MAY CAUSE VARIOUS SKIN DISORDERS
SUCH AS DERMATITIS, FOLLICULITIS OR OIL ACNE. RELEASE DURING
HIGH PRESSURE USAGE MAY RESULT IN INJECTION OF GREASE INTO THE
SKIN CAUSING LOCAL NECROSIS.
INHALATION: NOT EXPECTED TO BE A RELEVANT ROUTE OF EXPOSURE, HOWEVER, UNDE HIGH TEMPERATURE CONDITIONS, VAPORS IRRITATING TO THE NOSE,
THORAT AND UPPER RESPIRATORY TRACT MAY BE PRODUCED.
INGESTION: GREASES ARE GENERALLY CONSIDERED TO HAVE A LOW ORDER OF ACUTE
ORAL TOXICITY.
SIGNS AND SYMPTOMS: IRRITATION AS NOTED ABOVE. LOCAL NECROSIS IS EVIDENCED BY
DELAYED ONSET OF PAIN AND TISSUE DAMAGE A FEW HOURS
FOLLOWING INJECTION.
AGGRAVATED MEDICAL CONDITIONS:
PREEXISTING SKIN DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS PRODUCT.
OTHER HEALTH EFFECTS:
Commercial Food Equipment Service Association P_0000283583 D_0000307072




THIS PRODUCT AND ITS COMPONENTS ARE NOT CLASSIFIED AS CARCINOGENS BY
INTERNATIONAL AGENCY FOR RESEARCH ON CANCER (IARC), NATIONAL TOXOCOLOGY
PROGRAM (NTP) OR OCCUPATIONAL SAFETY AND HEALTH ADMINISTRATION (OSHA).
THIS SPECIFIC PRODUCT HAS NOT BEEN TESTED IN LONG-TERM, CHRONIC EXPOSURE
TESTS. LUBRICATING GREASES ARE GENERALLY CONSIDERED TO BE OF A LOW ORDER OF
ACUTE TOXICITY TO HUMANS AND EXPERIMENTAL ANIMALS. HOWEVER, THE HANDLING
PROCEDURES AND SAFETY PRECAUTIONS IN THIS MSDS SHOULD BE FOLLOWED TO
MINIMIZE EMPLOYEE'S EXPOSURE.
FOR A SPANISH TRANSLATION OF THIS MSDS, CALL 1-800-240- MSDS
_______________________________________________________________________________
SECTION IV OCCUPATIONAL EXPOSURE LIMITS
_______________________________________________________________________________
COMP OSHA ACGIH
NO. PEL/TWA PEL/CEILING TLV/TWA TLV/STEL OTHE --- ------- ----------- ------- -------- -----
NO OSHA/PEL OR ACGIH/TLV HAS BEEN ESTABLISHED.
_______________________________________________________________________________
SECTION V EMERGENCY AND FIRST AID PROCEDURES
_______________________________________________________________________________
EYE CONTACT: FLUSH WITH WATER FOR 15 MINUTES WHILE HOLDING EYELIDS OPEN. GET
MEDICAL ATTENTION.
SKIN CONTACT: REMOVE CONTAMINATED CLOTHING AND WIPE EXCESS OFF. WASH WITH SOAP
AND WATER OR A WATERLESS HAND CLEANER FOLLOWED BY SOAP AND WATER.
DO NOT REUSE CLOTHING UNTIL THOROUGHLY CLEANED. IF IRRITATION
PERSISTS, GET MEDICAL ATTENTION. IF MATERIAL IS INJECTED UNDE THE SKIN, GET MEDICAL ATTENTION PROMPTLY TO PREVENT SERIOUS
DAMAGE; DO NOT WAIT FOR SYMPTOMS TO DEVELOP.
INHALATION: REMOVE VICTIM TO FRESH AIR AND PROVIDE OXYGEN IF BREATHING IS
DIFFICULT. GET MEDICAL ATTENTION.
INGESTION: DO NOT INDUCE VOMITING. IN GENERAL, NO TREATMENT IS NECESSARY
UNLESS LARGE QUANTITIES OF PRODUCT ARE INGESTED. HOWEVER, GET
MEDICAL ADVICE.*
NOTE TO PHYSICIAN: *NOTE TO THE PHYSICIAN: IN GENERAL, EMESIS INDUCTION IS
UNNECESSARY IN HIGH VISCOSITY, LOW VOLATILITY PRODUCTS,
I.E., MOST OILS AND GREASES.
_______________________________________________________________________________
SECTION VI SUPPLEMENTAL HEALTH INFORMATION
_______________________________________________________________________________
NONE IDENTIFIED.
_______________________________________________________________________________
SECTION VII PHYSICAL DATA
_______________________________________________________________________________
BOILING POINT (DEG F): SPECFIC GRAVITY (H2O = 1): VAPOR PRESSURE (MM HG):
NOT AVAILABLE NOT AVAILABLE NOT AVAILABLE
MELTING POINT (DEG F): SOLUBILITY IN WATER: VAPOR DENSITY (AIR = 1):
500 (DROP POINT) INSOLUBLE NOT AVAILABLE
VISCOSITY: 30-34
(CS @ 100 DEG C)
EVAPORATION RATE (NORMAL BUTYL ACETATE = 1):NOT AVAILABLE
APPEARANCE AND ODOR:DARK AMBER, SMOOTH, SLIGHT ODOR.
PHYS/CHEM PROPERTIES: SEE ABOVE FOR DETAILS
_______________________________________________________________________________
SECTION VIII FIRE AND EXPLOSION HAZARDS
_______________________________________________________________________________
FLASH POINT AND METHOD: 550 DEG F. PMCC (BASE OIL)
FLAMMABLE LIMITS/PERCENT VOLUME IN AIR: LOWER: N/AV HIGHER: N/AV
EXTINGUISHING MEDIA:
USE WATER FOG, DRY CHEMICAL OR CO2. DO NOT USE A DIRECT STREAM OF WATER.
PRODUCT WILL FLOAT AND CAN BE REIGNITED ON SURFACE OF WATER.
SPECIAL FIRE FIGHTING PROCEDURES AND PRECAUTIONS:
Commercial Food Equipment Service Association P_0000283583 D_0000307072




DO NOT ENTER CONFINED FIRE SPACE WITHOUT PROPER PROTECTIVE EQUIPMENT
INCLUDING A NIOSH APPROVED SELF-CONTAINED BREATHING APPARATUS. COOL FIRE
EXPOSED CONTAINERS SURROUNDING EQUIPMENT AND STRUCTURES WITH WATER.
UNUSUAL FIRE AND EXPLOSION HAZARDS:
NONE IDENTIFIE _______________________________________________________________________________
SECTION IX REACTIVITY
_______________________________________________________________________________
STABLITY: STABLE HAZARDOUS POLYMERIZATION WILL NOT OCCU CONDITIONS AND MATERIALS TO AVOID:
AVOID HEAT, OPEN FLAME AND CONTACT WITH STRONG OXIDIZING AGENTS.
HAZARDOUS DECOMPOSITION PRODUCTS:
THERMAL DECOMPOSITION PRODUCTS ARE HIGHLY DEPENDENT ON THE COMBUSTION
CONDITIONS. A COMPLEX MIXTURE OF AIRBORNE SOLID, LIQUID PARTICULATES AN GASES WILL EVOLVE WHEN THIS MATERIAL UNDERGOES PYROLYSIS OR COMBUSTION.
CARBON MONOXIDE AND UNIDENTIFIED ORGANIC COMPOUNDS MAY BE FORMED UPON
COMBUSTION.
_______________________________________________________________________________
SECTION X EMPLOYEE PROTECTION
_______________________________________________________________________________
RESPIRATORY PROTECTION:
NOT ORDINARILY REQUIRED.
PROTECTIVE CLOTHING
USE OIL RESISTANT GLOVES AND OTHER CLOTHING AS NEEDED TO MINIMIZE SKIN
CONTACT.
ADDITIONAL PROTECTIVE MEASURES:
NONE IDENTIFIE _______________________________________________________________________________
SECTION XI ENVIRONMENTAL PROTECTION
_______________________________________________________________________________
SPILL OR LEAK PROCEDURES:
SCOOP UP EXCESS GREASE. CLEAN AREA WITH APPROPRIATE CLEANER.
_______________________________________________________________________________
SECTION XII SPECIAL PRECAUTIONS
_______________________________________________________________________________
STORE IN A COOL, DRY PLACE WITH ADEQUATE VENTILATION. KEEP AWAY FROM OPEN
FLAMES AND HIGH TEMPERATURES.
MINIMIZE SKIN CONTACT. WASH WITH SOAP AND WATER BEFORE EATING, DRINKING,
SMOKING OR USING TOILET FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE
REUSE. PROPERLY DISPOSE OF CONTAMINATED LEATHER ARTICLES, INCLUDING SHOES,
THAT CANNOT BE DECONTAMINATED.
_______________________________________________________________________________
SECTION XIII TRANSPORTATION REQUIREMENTS
_______________________________________________________________________________
DEPARTMENT OF TRANSPORTATION CLASSIFICATION:
NOT HAZARDOUS BY D.0.T. REGULATIONS
DOT PROPER SHIPPING NAME: NOT APPLICABLE
OTHER REQUIREMENTS: NOT APPLICABLE
_______________________________________________________________________________
SECTION XIV OTHER REGULATORY CONTROLS
_______________________________________________________________________________
THE COMPONENTS OF THIS PRODUCT ARE LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL
SUBSTANCES.
PROTECTION OF STRATOSPHERIC OZONE (PURSUANT TO SECTION 611 OF THE CLEAN AIR ACT
AMENDMENTS OF 1990): PER 40 CFR PART 82, THIS PRODUCT DOES NOT CONTAIN NO WAS IT DIRECTLY MANUFACTURED WITH ANY CLASS I OR CLASS II OZONE DEPLETING
SUBSTANCES.
IN ACCORDANCE WITH SARA TITLE III, SECTION 313, THE ENVIRONMENTAL DATA SHEET
(EDS) SHOULD ALWAYS BE COPIED AND SENT WITH THE MSDS.
_______________________________________________________________________________
Commercial Food Equipment Service Association P_0000283583 D_0000307072




SECTION XV STATE REGULATORY INFORMATION
_______________________________________________________________________________
STATE LISTED COMPONENT CAS NO PERCENT STATE CODE
_______________________________________________________________________________
BASED ON INFORMATION AVAILABLE, THIS PRODUCT DOES NOT CONTAIN ANY
CHEMICAL SUBSTANCE LISTED ON A CHEMICAL SPECIFIC STATE LIST.
_______________________________________________________________________________
SECTION XVI SPECIAL NOTES
_______________________________________________________________________________
REVISIONS IN SECTIONS I, III AND XV.
_______________________________________________________________________________
THE INFORMATION CONTAINED IN THIS DATA SHEET IS BASED ON THE DATA AVAILABLE
TO US AT THIS TIME, AND IS BELIEVED TO BE ACCURATE BASED UPON THAT DATA. IT IS
PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT, FOR PURPOSE OF HAZAR COMMUNICATION. IT IS NOT INTENDED TO CONSTITUTE PRODUCT PERFORMANCE
INFORMATION, AND NO EXPRESS OR IMPLIED WARRANTY OF ANY KIND IS MADE WITH
RESPECT TO THE PRODUCT, UNDERLYING DATA OR THE INFORMATION CONTAINE HEREIN. YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL PRODUCTS YOU BUY,
PROCESS, USE OR DISTRIBUTE, AND ARE ENCOURAGED TO ADVISE THOSE WHO MAY
COME IN CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN.

TO DETERMINE THE APPLICABILITY OR EFFECT OF ANY LAW OR REGULATION WITH
RESPECT TO THE PRODUCT, YOU SHOULD CONSULT WITH YOUR LEGAL ADVISOR OR THE
APPROPRIATE GOVERNMENT AGENCY. WE WILL NOT PROVIDE ADVICE ON SUCH
MATTERS, OR BE RESPONSIBLE FOR ANY INJURY FROM THE USE OF THE PRODUCT
DESCRIBED HEREIN. THE UNDERLYING DATA, AND THE INFORMATION PROVIDED HEREIN
AS A RESULT OF THAT DATA, IS THE PROPERTY OF EQUIVA SERVICES, LLC AND IS NOT TO
BE THE SUBJECT OF SALE OR EXCHANGE WITHOUT THE EXPRESS WRITTEN CONSENT OF
EQUIVA SERVICES, LLC.
_______________________________________________________________________________
ENVIRONMENTAL DATA SHEET
EQUILON EDS: 56230E
AEROSHELL(R) GREASE 5
TELEPHONE NUMBER:
24 HOUR EMERGENCY ASSISTANCE GENERAL MSDS ASSISTANCE
EQUIVA SERVICES: 877-276-7283 877-276-7285
CHEMTREC: 800-424-9300
NAME AND ADDRESS
EQUILON ENTERPRISES
PRODUCT STEWARDSHIP
P.O. BOX 674414
HOUSTON, TX 77267-4414
PRODUCT CODE: 70025
_______________________________________________________________________________
SECTION I PRODUCT COMPOSITION
_______________________________________________________________________________
NO. COMPOSITION CAS PERCENT
===============================================================================
P AEROSHELL GREASE 5 MIXTURE 100
1 SOLVENT REFINED; HYDROTREATED RESIDUAL O 64742-57-0 89.0
IL
2 INORGANIC CLAY 1302-78-9 6.0
3 FATTY ACID AMIDES 68910-93-0 3.0
4 OTHER COMPONENTS MIXTURE <3.0
_______________________________________________________________________________
SECTION II SARA TITLE III INFORMATION
_______________________________________________________________________________
NO. EHS RQ EHS TPQ SEC-313 313 CATEGORY 311/312 CATEGORY
(*1) (*2) (*3) (*4) (*5)
===============================================================================
Commercial Food Equipment Service Association P_0000283583 D_0000307072




BASED ON THE DATA AVAILABLE THIS PRODUCT CONTAINS NO SUBSTANCES
SUBJECT TO REPORTING OR PLANNING REQUIREMENTS UNDER SARA TITLE III.
_______________________________________________________________________________
*1 = REPORTABLE QUANTITY OF EXTREMELY HAZARDOUS SUBSTANCE, SEC 302
*2 = THRESHOLD PLANNING QUANTITY, EXTREMELY HAZARDOUS SUBSTANCE, SEC 302
*3 = TOXIC CHEMICAL, SEC 313
*4 = CATEGORY AS REQUIRED BY SEC 313 (40 CFR 372.65 C), MUST BE USED ON TOXIC
RELEASE INVENTORY FORM
*5 = CATEGORY (FOR AGGREGATE REPORTING REQUIREMENTS UNDER SARA 311, 312)
HEALTH: H-1 = IMMEDIATE (ACUTE) HEALTH HAZAR H-2 = DELAYED (CHRONIC) HEALTH HAZAR PHYSICAL: P-3 = FIRE HAZAR P-4 = SUDDEN RELEASE OF PRESSURE HAZAR P-5 = REACTIVE HAZAR _______________________________________________________________________________
SECTION III ENVIRONMENTAL RELEASE INFORMATION
_______________________________________________________________________________
THIS PRODUCT IS COVERED BY EPA'S COMPREHENSIVE ENVIRONMENTAL RESPONSE,
COMPENSATION AND LIABILITY ACT (CERCLA) PETROLEUM EXCLUSION. THEREFORE
RELEASES TO AIR, LAND, OR WATER ARE NOT REPORTABLE UNDER CERCLA
("SUPERFUND"). HOWEVER UNDER SECTION 311 OF EPA'S CLEAN WATER ACT (CWA),
THIS PRODUCT IS CONSIDERED AN OIL. AS SUCH , SPILLS INTO OR LEADING TO
SURFACE WATERS THAT CAUSE A SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE
CENTER, 800-424-8802.
THIS PRODUCT IS AN OIL UNDER 49 CFR (DOT) PART 130. IF SHIPPED BY RAIL O HIGHWAY IN A TANK WITH A CAPACITY OF 3,500 GALLONS OR MORE, IT IS SUBJECT TO
THE REQUIREMENTS OF PART 130. MIXTURE SOLUTIONS IN WHICH THIS PRODUCT IS
PRESENT AT 10% OR MORE MAY ALSO BE SUBJECT TO THIS RULE.
_______________________________________________________________________________
SECTION IV RCRA INFORMATION
_______________________________________________________________________________
IF THIS PRODUCT BECOMES A WASTE, IT WOULD NOT BE A HAZARDOUS WASTE BY RCRA
CRITERIA (40 CFR 261). PLACE IN AN APPROPRIATE DISPOSAL FACILITY IN
COMPLIANCE WITH LOCAL REGULATIONS.
_______________________________________________________________________________
THE INFORMATION CONTAINED IN THIS DATA SHEET IS BASED ON THE DATA AVAILABLE
TO US AT THIS TIME, AND IS BELIEVED TO BE ACCURATE BASED UPON THAT DATA. IT IS
PROVIDED INDEPENDENTLY OF ANY SALE OF THE PRODUCT, FOR PURPOSE OF HAZAR COMMUNICATION. IT IS NOT INTENDED TO CONSTITUTE PRODUCT PERFORMANCE
INFORMATION, AND NO EXPRESS OR IMPLIED WARRANTY OF ANY KIND IS MADE WITH
RESPECT TO THE PRODUCT, UNDERLYING DATA OR THE INFORMATION CONTAINE HEREIN. YOU ARE URGED TO OBTAIN DATA SHEETS FOR ALL PRODUCTS YOU BUY,
PROCESS, USE OR DISTRIBUTE, AND ARE ENCOURAGED TO ADVISE THOSE WHO MAY
COME IN CONTACT WITH SUCH PRODUCTS OF THE INFORMATION CONTAINED HEREIN.

TO DETERMINE THE APPLICABILITY OR EFFECT OF ANY LAW OR REGULATION WITH
RESPECT TO THE PRODUCT, YOU SHOULD CONSULT WITH YOUR LEGAL ADVISOR OR THE
APPROPRIATE GOVERNMENT AGENCY. WE WILL NOT PROVIDE ADVICE ON SUCH
MATTERS, OR BE RESPONSIBLE FOR ANY INJURY FROM THE USE OF THE PRODUCT
DESCRIBED HEREIN. THE UNDERLYING DATA, AND THE INFORMATION PROVIDED HEREIN
AS A RESULT OF THAT DATA, IS THE PROPERTY OF EQUIVA SERVICES, LLC AND IS NOT TO
BE THE SUBJECT OF SALE OR EXCHANGE WITHOUT THE EXPRESS WRITTEN CONSENT OF
EQUIVA SERVICES, LLC.
_______________________________________________________________________________
KAREN G. HAYNES
---------------
EQUIVA SERVICES LLC
P.O. BOX 674414
HOUSTON, TX 77267-4414
FOR ADDITIONAL INFORMATION ON THIS ENVIRONMENTAL DATA PLEASE CALL
Commercial Food Equipment Service Association P_0000283583 D_0000307072




(877) 276-7285
FOR EMERGENCY ASSISTANCE PLEASE CALL
EQUIVA SERVICES LLC: (877) 276-7283
CHEMTREC: (800) 424-9300
}


Residual oils(petroleum), hydrotreated