1.Identification

1.1 GHS Product identifier

1.2 Other means of identification

1.3 Recommended use of the chemical and restrictions on use

1.4 Supplier's details

1.5 Emergency phone number

2.Hazard identification

2.1 Classification of the substance or mixture

Acute toxicity - Oral, Category 2

Acute toxicity - Dermal, Category 3

Acute toxicity - Inhalation, Category 2

Germ cell mutagenicity, Category 2

Hazardous to the aquatic environment, short-term (Acute) - Category Acute 1

Hazardous to the aquatic environment, long-term (Chronic) - Category Chronic 1

2.2 GHS label elements, including precautionary statements

Pictogram(s)
Signal word	Danger
Hazard statement(s)	H300 Fatal if swallowed H311 Toxic in contact with skin H330 Fatal if inhaled H341 Suspected of causing genetic defects H410 Very toxic to aquatic life with long lasting effects
Precautionary statement(s)
Prevention	P264 Wash ... thoroughly after handling. P270 Do not eat, drink or smoke when using this product. P280 Wear protective gloves/protective clothing/eye protection/face protection. P260 Do not breathe dust/fume/gas/mist/vapours/spray. P271 Use only outdoors or in a well-ventilated area. P284 [In case of inadequate ventilation] wear respiratory protection. P201 Obtain special instructions before use. P202 Do not handle until all safety precautions have been read and understood. P273 Avoid release to the environment.
Response	P301+P310 IF SWALLOWED: Immediately call a POISON CENTER/doctor/… P321 Specific treatment (see ... on this label). P330 Rinse mouth. P302+P352 IF ON SKIN: Wash with plenty of water/... P312 Call a POISON CENTER/doctor/…if you feel unwell. P361+P364 Take off immediately all contaminated clothing and wash it before reuse. P304+P340 IF INHALED: Remove person to fresh air and keep comfortable for breathing. P310 Immediately call a POISON CENTER/doctor/… P320 Specific treatment is urgent (see ... on this label). P308+P313 IF exposed or concerned: Get medical advice/ attention. P391 Collect spillage.
Storage	P405 Store locked up. P403+P233 Store in a well-ventilated place. Keep container tightly closed.
Disposal	P501 Dispose of contents/container to ...

2.3 Other hazards which do not result in classification

none

3.Composition/information on ingredients

3.1 Substances

4.First-aid measures

4.1 Description of necessary first-aid measures

General advice

Consult a physician. Show this safety data sheet to the doctor in attendance.

If inhaled

Fresh air, rest. Half-upright position. Artificial respiration may be needed. Refer immediately for medical attention.

In case of skin contact

Remove contaminated clothes. Rinse and then wash skin with water and soap. Refer immediately for medical attention. Wear protective gloves when administering first aid.

In case of eye contact

Rinse with plenty of water (remove contact lenses if easily possible). Refer immediately for medical attention.

If swallowed

Rinse mouth. Give a slurry of activated charcoal in water to drink. Do NOT induce vomiting. Refer immediately for medical attention. See Notes.

4.2 Most important symptoms/effects, acute and delayed

Monocrotophos is an organophosphorus pesticide. It is a cholinesterase inhibitor and acts on the nervous system. Extremely toxic; probable oral lethal dose to humans 5-50 mg/kg or between 7 drops and 1 teaspoon for a 70 kg (150 lb.) person. Repeated inhalation or skin contact with this material may, without symptoms, progressively increase susceptibility to poisoning. (EPA, 1998)

4.3 Indication of immediate medical attention and special treatment needed, if necessary

Antidote: Atropine combined with oxime preparation, e.g. PAM or Toxogonin. Atropine is the emergency antidote for Azodrin poisoning. 2-PAM is also antidotal and may be used in conjunction with atropine. Do not use morphine.

5.Fire-fighting measures

5.1 Extinguishing media

Suitable extinguishing media

Use water, foam, carbon dioxide, or dry chemical to extinguish fires. /Malathion/

5.2 Specific hazards arising from the chemical

Wear positive pressure breathing apparatus and full protective clothing. Container may explode in heat of fire. Toxic fumes evolved when heated to decomposition. Incompatible with alkaline compounds. Unstable in aqueous solution above pH 7.0; in low molecular weight alcohols and glycols. Stable in ketones and higher molecular weight alcohols and glycols. Stable when stored in glass or polyethylene containers. Relatively stable in sunlight. Keep away from temperatures above 80F; do not store below 70F. Corrosive to black iron, drum steel, stainless steel 304 and brass, but not to glass, aluminum, or stainless steel 316. (EPA, 1998)

5.3 Special protective actions for fire-fighters

Wear self-contained breathing apparatus for firefighting if necessary.

6.Accidental release measures

6.1 Personal precautions, protective equipment and emergency procedures

Use personal protective equipment. Avoid dust formation. Avoid breathing vapours, mist or gas. Ensure adequate ventilation. Evacuate personnel to safe areas. Avoid breathing dust. For personal protection see section 8.

6.2 Environmental precautions

Personal protection: complete protective clothing including self-contained breathing apparatus. Do NOT let this chemical enter the environment. Sweep spilled substance into covered sealable, plastic containers. If appropriate, moisten first to prevent dusting. Carefully collect remainder. Then store and dispose of according to local regulations.

6.3 Methods and materials for containment and cleaning up

Spills of malathion on floors shall be absorbed with absorbing clay. Sweeping compound may be utilized to facilitate the removal of all visible traces of malathion contaminated clay. Equipment and fixtures contaminated with malathion shall be decontaminated with an alkaline solution (5% sodium hydroxide). /Malathion/

7.Handling and storage

7.1 Precautions for safe handling

Avoid contact with skin and eyes. Avoid formation of dust and aerosols. Avoid exposure - obtain special instructions before use.Provide appropriate exhaust ventilation at places where dust is formed. For precautions see section 2.2.

7.2 Conditions for safe storage, including any incompatibilities

Provision to contain effluent from fire extinguishing. Separated from food and feedstuffs. Dry. Well closed. Keep in a well-ventilated room. Store in an area without drain or sewer access.DO NOT STORE /AZODRIN 5/ BELOW 70 DEG F OR ABOVE 80 DEG F FOR PROLONGED PERIODS. AZODRIN 5 IS EXTREMELY FLAMMABLE.

8.Exposure controls/personal protection

8.1 Control parameters

Occupational Exposure limit values

Recommended Exposure Limit: 10 Hr Time-Weighted Avg: 0.25 mg/cu m.

Biological limit values

no data available

8.2 Appropriate engineering controls

Handle in accordance with good industrial hygiene and safety practice. Wash hands before breaks and at the end of workday.

8.3 Individual protection measures, such as personal protective equipment (PPE)

Eye/face protection

Safety glasses with side-shields conforming to EN166. Use equipment for eye protection tested and approved under appropriate government standards such as NIOSH (US) or EN 166(EU).

Skin protection

Wear impervious clothing. The type of protective equipment must be selected according to the concentration and amount of the dangerous substance at the specific workplace. Handle with gloves. Gloves must be inspected prior to use. Use proper glove removal technique(without touching glove's outer surface) to avoid skin contact with this product. Dispose of contaminated gloves after use in accordance with applicable laws and good laboratory practices. Wash and dry hands. The selected protective gloves have to satisfy the specifications of EU Directive 89/686/EEC and the standard EN 374 derived from it.

Respiratory protection

Wear dust mask when handling large quantities.

Thermal hazards

no data available

9.Physical and chemical properties

10.Stability and reactivity

10.1 Reactivity

no data available

10.2 Chemical stability

On hydrolysis @ 20°C, the calculated half-life at pH 5 = 96 days, at pH 7 = 66 days, and at pH 9 = 17 days.

10.3 Possibility of hazardous reactions

AZODRIN 5 IS EXTREMELY FLAMMABLE.MONOCROTOPHOS is incompatible with the following: Metals, low molecular weight alcohols & glycols [Note: Corrosive to black iron, drum steel, stainless steel 304 & brass. Should be stored at 70-26.67°C.] (NIOSH, 2016). Incompatible with alkaline compounds.

10.4 Conditions to avoid

no data available

10.5 Incompatible materials

... Incompatible with /pesticides/ which are alkaline in reaction.

10.6 Hazardous decomposition products

WHEN HEATED TO DECOMPOSITION IT EMITS VERY TOXIC FUMES.

11.Toxicological information

Acute toxicity

• Oral: LD50 Rat oral 21 mg/kg
• Inhalation: LC50 rat inhalation (4 hr) = circa 0.08 mg/L
• Dermal: LD50 Rabbit percutaneous 112-709 mg/kg

Skin corrosion/irritation

no data available

Serious eye damage/irritation

no data available

Respiratory or skin sensitization

no data available

Germ cell mutagenicity

no data available

Carcinogenicity

A4; Not classifiable as a human carcinogen.

Reproductive toxicity

no data available

STOT-single exposure

no data available

STOT-repeated exposure

no data available

Aspiration hazard

no data available

12.Ecological information

12.1 Toxicity

• Toxicity to fish: LC50 Bluegill 12.1 mg/l/96 hr (95% confidence limit 7.2-10.1 mg/l) /as stated in source/, wt 1.0 g. Static bioassay without aeration, pH 7.2-7.5, water hardness 40-50 mg/l as calcium carbonate and alkalinity of 30-35 mg/l. /Technical material, 100%
• Toxicity to daphnia and other aquatic invertebrates: no data available
• Toxicity to algae: no data available
• Toxicity to microorganisms: no data available

12.2 Persistence and degradability

The soil algae, Chlorella vulgaris, Scenedesmus bijugatus, Synechococcus elongatus, Phormidium tenue, and Nostoc linckia, began metabolizing monocrotophos following 10 days of incubation(1). Monocrotophos is rapidly degraded in soil with half-lives ranging from 1 to 5 days(2). The half-life of azodrin in culture solution was 4.6 days(3). 100% of monocrotophos persisted after eight weeks incubation in raw river water(4).

12.3 Bioaccumulative potential

An estimated BCF value of 0.41 was calculated for monocrotophos(SRC), using an estimated log Kow of -0.20(1,SRC) and a recommended regression-derived equation(2). According to a classification scheme(3), this BCF value suggests that bioconcentration in aquatic organisms is low(SRC).

12.4 Mobility in soil

The Koc of monocrotophos is estimated as approximately 19(SRC), using a measured log Kow of -0.20(1) and a regression-derived equation(2,SRC). According to a recommended classification scheme(3), this estimated Koc value suggests that monocrotophos is expected to have very high mobility in soil(SRC).

12.5 Other adverse effects

no data available

13.Disposal considerations

13.1 Disposal methods

Product

The material can be disposed of by removal to a licensed chemical destruction plant or by controlled incineration with flue gas scrubbing. Do not contaminate water, foodstuffs, feed or seed by storage or disposal. Do not discharge to sewer systems.

Contaminated packaging

Containers can be triply rinsed (or equivalent) and offered for recycling or reconditioning. Alternatively, the packaging can be punctured to make it unusable for other purposes and then be disposed of in a sanitary landfill. Controlled incineration with flue gas scrubbing is possible for combustible packaging materials.

14.Transport information

14.1 UN Number

14.2 UN Proper Shipping Name

14.3 Transport hazard class(es)

14.4 Packing group, if applicable

14.5 Environmental hazards

14.6 Special precautions for user

no data available

14.7 Transport in bulk according to Annex II of MARPOL 73/78 and the IBC Code

no data available

15.Regulatory information

15.1 Safety, health and environmental regulations specific for the product in question

16.Other information

Information on revision

Abbreviations and acronyms

• CAS: Chemical Abstracts Service
• ADR: European Agreement concerning the International Carriage of Dangerous Goods by Road
• RID: Regulation concerning the International Carriage of Dangerous Goods by Rail
• IMDG: International Maritime Dangerous Goods
• IATA: International Air Transportation Association
• TWA: Time Weighted Average
• STEL: Short term exposure limit
• LC50: Lethal Concentration 50%
• LD50: Lethal Dose 50%
• EC50: Effective Concentration 50%

References

• IPCS - The International Chemical Safety Cards (ICSC), website: http://www.ilo.org/dyn/icsc/showcard.home
• HSDB - Hazardous Substances Data Bank, website: https://toxnet.nlm.nih.gov/newtoxnet/hsdb.htm
• IARC - International Agency for Research on Cancer, website: http://www.iarc.fr/
• eChemPortal - The Global Portal to Information on Chemical Substances by OECD, website: http://www.echemportal.org/echemportal/index?pageID=0&request_locale=en
• CAMEO Chemicals, website: http://cameochemicals.noaa.gov/search/simple
• ChemIDplus, website: http://chem.sis.nlm.nih.gov/chemidplus/chemidlite.jsp
• ERG - Emergency Response Guidebook by U.S. Department of Transportation, website: http://www.phmsa.dot.gov/hazmat/library/erg
• Germany GESTIS-database on hazard substance, website: http://www.dguv.de/ifa/gestis/gestis-stoffdatenbank/index-2.jsp
• ECHA - European Chemicals Agency, website: https://echa.europa.eu/

Disclaimer: The above information is believed to be correct but does not purport to be all inclusive and shall be used only as a guide. The information in this document is based on the present state of our knowledge and is applicable to the product with regard to appropriate safety precautions. It does not represent any guarantee of the properties of the product. We as supplier shall not be held liable for any damage resulting from handling or from contact with the above product.